Quantcast
Jump to content

2020 Hisun 750 cuts off


Recommended Posts

So my wife picked out a brand new Hisun crew 4x4 750 axis 4x4. When it gets hot it shuts off. This vehicle has less than 20 miles. I'm the dark here. First I have no access to a trouble shooting guide and have even blindly performed the "wiggle tests" as I used to do as a drive ability tech on cars professionally. I'm not able to locate what's getting overheated to cause it to shut off. After awhile it'll start right up and no issues. While trying to duplicate the problem sitting at idle, it'll eventually cut off again. Again when cooled off will start again. 

 

I'm hating this machine and wished she'd gone with a pricier but more reliable sxs. My grizzly 550 rarely gives me issues that isn't my fault. 

Link to comment
Share on other sites

  • 2 weeks later...

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

 Share

  • Similar Topics

    • By Gorj
      I have had my E1 since late last summer and I have always noticed that the parking brake was weak or non existent. About a month or so after I purchased it I mentioned to the dealer that the parking brake did not function well. What I was expecting from the dealer, ' well bring it in and we will correct the issue.' What I got was the typical dealer response, "it may just need to be adjusted." No shit!  Well I finally decided to adjust it. A very simple process need only two 10mm wrenches.  Open the bed, remove the pin holding the bed  to the strut and move the bad out of the way. Right in front of the electric motor is a brake disk.  That is the parking brake. It has a small set of brake pads that are actuated by a lever attached to parking brake cable.  There are two 10 mm nuts on the shaft to moves the pads. Release the inner nut and hold it in place while screwing in the outer nut - that is really a bolt. After screwing it in about one turn, tighten the other nut.  Check the parking brake. If it is holding when activated, then you are good, but if not, then you may have to turn the bolt another turn. Do not turn to far or you will lock it up.
    • By Billsectere
      New to the forum. New to UTVs. New to Electric motors.  I just got a 2021 Hisun Sector E to help with moving stuff on my  steep 5 acre wooded mountain patch. Plus I thought it would be fun on the gravel roads in the "neighborhood". Because we are remote and part time to the property, I didn't want the hassle of dumping out old gas or messing with oil and filters and all the usual maintenance of a ICE. But the biggest reason for me was the noise. I test drove the Axis utvs at Tractor Supply Co and they were LOUD. Seemed to ride rough too. If you want quiet, then electric is the way to go. But it does come with a high price tag. And all the electric models are still in their infancy. So its a bit of a gamble too. I bought the property for quiet. I wanted to keep it quiet.
      I liked that the Hisun had the dry cell batteries so there is no maintenance of checking and adding water. I'm a little worried about their lifespan especially after one person's poor utube review about them. But the dealer said the company took that to heart so hopefully changes were made for better batteries. There were no Lithium battery options available anywhere near me. Polaris is supposed to have one later this year. I liked that the Hisun came standard with roof, windshield, winch and trailer hitch. I have had the sector for only one day and worked it and road it good. So far I have a big smile on my face. I wish there was a category for this model on the forum here. Meanwhile, maybe folks will share their insights/ experiences on this thread. I'd like to learn as much about the sector e as I can. There isn't much info in the owners manual.
       

    • By Tombo
      How can i Disconnect Hisun 700 2017 UTV  40 km/h speed limiter ? Preferably with a switch. 
       
       
       
    • By EJW
      I have a 2011-12 Hisun Yard Sport HS700. Engine gets hot, but radiator does not. Changed the water pump, still the same. Service manual parts #15, 16, & 17 (pages 283-284) shows a "Save Temperture" #15, which looks like a thermostat. Service manual also parts #9, 10 & 11 shows it without a thermostat. Does this unit have a thermostat?
    • eManualOnline
    • By Fib103182
      I have owned my 2015 Hisun HS700 Crew  for about 3 or 4 months now. I got it used and was supposed to run good but was not put all the back together from a stator upgrade due to previous owner said he was going to out a stereo system on it. Anyway I have worked it much more than I have rode it. I seem to work on it 2 days and ride it for a hour. Me, my wife, and 2 kids (10 and 18) enjoy it but the engine compartment gets so hot. I've replaced the water pump and burped the cooling system and any other thing I could think of to bleed the air out and think its good with no air and water circulating. Fan seems to run fine and be on about all the time. Changed the coolant twice and oil 3 times. I noticed the engine really has nowhere for heat to go because heat rises and no air flow at all. Has anyone had any experience in this area? Any DIY tricks or any advice in removing the heat out of the engine compartment and getting it to a tolerable temperature. Im about to sell it if I can't figure something out and go waste money on a big name brand but I won't have red legs and arm from engine heat burning me and my wife. They machine never acts like its to hot or anything but it feels like it is. Thanks in advance for any and all help. 
  • Similar Tagged Content

    • By John m
      I’ve got a Hisun 750 that will all of a sudden just shut down, like it lost all power. Once it sets for a while it will start working again. Put it not getting hot so I’m having trouble trying to figure out what’s wrong with it. Does anyone know what it it?
    • By Utv
      Coolant dripping out of weep hole

    • By Hisun750Mud
      This seems to be the most active forum for Hisun so if I purchase here is my new home!  I want the UTV mainly for trail riding and some mudding with the family which is the reason for the four seats.  I'm looking to pick up a 2016 HS Crew for around 5,000 which seems to be a good deal.  The bike is in great shape and has low hours but the concern I have is the lack of parts.  I'm not sure if it's known by another name (I've heard Rhino is 1-1 interchangeable) but when I Google, ebay, or Amazon "2016 Hisun 750 HS" very few parts come up.  I'm concerned that if I break an arm, shock, or tie rod I'll be forced to go to the dealer.  I also see a lack of performance parts for the Hisun vs things like a Kawasaki Tryex.  There seems to be a bigger community around the other bikes where there are people who have custom flashes and such, not so much for the Hisun.  Am I looking in the right places or should I steer clear?
  • Gallery Images


×
×
  • Create New...