Quantcast
Jump to content


cutout related to wiring error


Recommended Posts

Posted

My Trooper has been cutting out when I would let up on the throttle. Just quit then run ok again. It always ran fine when I was down on the throttle, it just happened when I was letting off. Though I had a wire shorting or continunity problem that showed up when a wire shifted forward a speck when letting up. I think I may have found the problem. so far haven't found any wire related issues but did find a wiring error. I replaced the Oxygen sensors on my Trooper and in doing so had to cut the plugs off the old sensors and put them on the new sensors. One wire is a little longer then the other because it reaches to the downstream sensor. Well, I put the longer wired plug on the upstream sensor and vise-versa. It ran fine when accelerating, because both sensors saw extra oxygen so it provided extra fuel for it. But, when I let up on it, the downstream sensor which was now reading from the upstream position would see a shortage of oxygen because there is a speck of time that the engine runs rich when letting up on the throttle. I suspect that normally the sensor that is downstream, after the catylitic comverter, looks for a different fuel oxygen ratio then the upstream one. It probably doesn't care if it's running lean because it only wants to see enough oxygen to burn off any remaining fuel componets for clean emmision. If it doesn't see any oxygen during that instant of letup, I suspect that the computer cuts the fuel until it sees some oxygen. The computer would react differently to the normally upstream sensor's signal. Haven't tested the fix yet, still have some wires I want to check as long as I'm almost thru all of them and apart. Will let you know. Had I not carefully checked every wire and where they were susposed to go from each computer plug pin I could have easily not found this issue and could have been fighting it for ever. Gosh, I hate it when I make mistakes which is more often then I like to admit.

Lenny

Posted

My Trooper has been cutting out when I would let up on the throttle. Just quit then run ok again. It always ran fine when I was down on the throttle, it just happened when I was letting off. Though I had a wire shorting or continunity problem that showed up when a wire shifted forward a speck when letting up. I think I may have found the problem. so far haven't found any wire related issues but did find a wiring error. I replaced the Oxygen sensors on my Trooper and in doing so had to cut the plugs off the old sensors and put them on the new sensors. One wire is a little longer then the other because it reaches to the downstream sensor. Well, I put the longer wired plug on the upstream sensor and vise-versa. It ran fine when accelerating, because both sensors saw extra oxygen so it provided extra fuel for it. But, when I let up on it, the downstream sensor which was now reading from the upstream position would see a shortage of oxygen because there is a speck of time that the engine runs rich when letting up on the throttle. I suspect that normally the sensor that is downstream, after the catylitic comverter, looks for a different fuel oxygen ratio then the upstream one. It probably doesn't care if it's running lean because it only wants to see enough oxygen to burn off any remaining fuel componets for clean emmision. If it doesn't see any oxygen during that instant of letup, I suspect that the computer cuts the fuel until it sees some oxygen. The computer would react differently to the normally upstream sensor's signal. Haven't tested the fix yet, still have some wires I want to check as long as I'm almost thru all of them and apart. Will let you know. Had I not carefully checked every wire and where they were susposed to go from each computer plug pin I could have easily not found this issue and could have been fighting it for ever. Gosh, I hate it when I make mistakes which is more often then I like to admit.

Lenny

You are correct you can't have those two sensors switched the one after the cat is monitoring efficiency so it's looking for a consistent value not up down up down like your 02. What kind of o2 sensors did you use and part number?

Posted

You are correct you can't have those two sensors switched the one after the cat is monitoring efficiency so it's looking for a consistent value not up down up down like your 02. What kind of o2 sensors did you use and part number?

I used a Bosch #13007 from Checkers for $89 then bought the second one, same bosch from NAPA for $74. If you have to change them, you will probably have to put the old connector on the new one. That is what I did, The 2 white wires on the new connector are the 12v heater wires. Use a meter to find the two 12 volt DC wires commng from the computer. Check this at the plug for the O2 sensor, not the one on the sensor it self. You can have the sensor unplugged for this and you must have the ignition on. Once established, cut and splice the 12v leads to the two white wires on the new sensor. Then hook the Grey to the grey and the black to the white and youir done.

After changing around the oxygen sensors it did run stronger, pulled harder. However it is still cutting out so now I'm going to look at the fuel system. It is popping a bit when it cuts out so that makes me think it gets lean. I'll be tearing into that this afternoon. I'll post what I find. Hopefully I find something.

Lenny

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

  • Similar Topics

    • By rdc
      Hope I posted this in the right place. Looking for the left side shaft carrier where the rear bearings go for an 1100cc sand viper, I understand an 800 cc carrier will also work. I need the old style two bearing with the spacer in the middle, the new style with just the one wide bearing wont work. If anybody has one I'll buy it right away. my email is [email protected]
    • By Butch
      I have a AXIS 700 EFI Fuel pump pressure stays at 40 psi and when return line is blocked the pressure goes to 60 psi. and wll only run with return line closed. 
    • By Jeff freeman
      I have a Coleman 550.  Was having problems to start with where it would start and then shut off after a couple tries. It would take off and be good. It then got to a point where it would not start at all. I replaced the fuel injection twice the second time I replaced it I noticed a mouse or something had chewed one of the wires that connect the electrical to the fuel injector. . So two-part question first does anybody have a part number for that wire harness?  Second, any other ideas after I fix the wire harness permanently on what could keep it from starting I have gas flow up to the fuel injector.


    • By Rmillerdesigns
      Hello. I have a 2016 Massimo MSU 500. I was putting on a lightbar and i screwed up and didn't disconnect the battery so when i was taking of the positive cable to put on the power from the lightbar it sparked and now the utv has no power. I turn the key over and all i hear is a chirp. No lights or anything. Everything that comes from the battery to the jumper box up by the battery shows voltage but anything coming out does not such as to the winch or anything like that
    • By J Cardwell
      2024 villian overheating shuts down to crawl mode. If I turn it off for 30 minutes power returns to normal. 
×
×
  • Create New...