Quantcast
Jump to content


Kawasaki issues PRO UTV recall

Travis

By Travis
in Kawasaki UTV SxS Forum

 Share

Recommended Posts

Travis Grand Master

Travis

Posted
Posted

The following product safety recall is being conducted voluntarily by Kawasaki in cooperation with the CPSC. Consumers should stop using the product immediately unless otherwise instructed. For more information about recalls, visit CPSC’s website at http://www.cpsc.gov.

Name of Product: MULE™ PRO

Units: Approximately 1,000.

Distributor: Kawasaki Motors Corp., U.S.A., Foothill Ranch, CA

Hazard: There is a possibility that an incorrect grade of material was used to manufacture the ROPS crossmember of the roll over protective structure which does not meet the intended tensile strength.

Description: The recall involves 2018 model year MULE™ PRO DXT, DX and 2019 model year MULE™ PRO FXT, FX, and FXR utility vehicles.

Sold at: Kawasaki dealers nationwide from August 31, 2018 to September 22, 2018 for between $13,100 and $17,000.

Remedy: Consumers should immediately stop using the product and contact your Kawasaki dealer to schedule a free repair. The repair consists of replacing the ROPS crossmember.

Consumer Contact: Kawasaki toll free at 866-802-9381 from 8 a.m. to 5 p.m. PT Monday through Friday.

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

×
 Share
Go to topic listing

  • Similar Topics

    • mike.s.
      Kawasaki mule model 2010, 4x4, gas motor, sell or trade
      By mike.s.
      SOLD 
       
       
       
       
    • JWS
      Engine Problem, Hard to Start. Kawasaki 08 600 Mule. Long Post.
      By JWS
      Help Please!
      Last year my Mule started running bad and was hard to start. NOT a battery or starter problem. I replace the carb with one of those cheap Chinese carbs from Amazon. Problem got worse. So, I replaced the fuel pump, one from Kawasaki, fuel filter and lines. Then replaced the fuel pump line to the engine. Finally bought a Kawasaki carb. Everything was ok till I filled the gas tank with fresh gas then it started running bad and hard to start again. The tank is clean. Gas is fresh, AGAIN. Filter is new. When running it has an occasional misfire. Managed to burn about a gallon out of the tank. Runs better. Replaced the gas cap in case it wasn't venting. No change. When running, if you try to go full throttle, it bogs down. The gas is good. I use it in my mower with no problem. The stater was replaced about one year ago and the flywheel cleaned inside. Still seams like a fuel problem but I'm at a loss. It's going back to the mechanic shop today. We use the Mule every day, live on a farm. It's never sat up. It has 1045hrs on it. New battery and starter.
      Any ideas?
    • nowgrn4
      Kawasaki Mule 550 valve lash specs
      By nowgrn4
      New to me , '04 with 2,438 hours. 286cc air cooled single cylinder. Anyone have them? I've seen set both at 005, 010, 012, 015, intake 012 and exhaust at 015. lol
    • Tom-C
      RTV recall
      By Tom-C
      My X1130 is involved in the recall.  It is a long way to the dealer.  does anyone have a drawing with the torque specs so I can do it myself?
    • Edelbrock
      What UTV should I buy?
      By Edelbrock
      So I'm interested in a side by side of some sort.
      Not sure what make/model to even look at.
       
      I would plan on riding on trails with very rough rocky terrain and plenty of mud. Maybe sand once in a long while. I like LOTS of power and drive fast, but also like a trail that is a challenge to get through. I think 4x4 would be a must. I like the idea of a supercharged engine, but I have never owned one, and would be a little concerned about long term reliability or expensive difficult engine repairs. If anyone knows quads, my favorite was the 2008 Polaris Outlaw 525 IRS. For dirt bikes, I raced a 2008 KTM 450 SX-F. So that gives you an idea of what type of off road stuff I liked.
      I don't like "utility quads" or "trail bikes". And likewise, I dont want a turd UTV. I want something that looks awesome and performs awesome. 2 seater with some cargo capacity at the minimum.
       
       
      Thoughts?

UTV FORUMS

MORE SECTIONS

FOLLOW US ON

GET IN TOUCH

  • Automotive Webmaster
×
×
  • Create New...