Quantcast
Jump to content

2016 Hisun 500 turns over,no start


Recommended Posts

2016, Hisun 500 turns over great but Spark plug is firing when I turn the ignition key on. I’ve got good fuel pressure to the injector. Pulled plug out and it is wet with. gasoline. Air filter is clean. Turns over great just does not even try to pop or start.. I’ve checked off uses and they are good when I turn the key on I’m getting power to the injector.. I’m not hearing the injector pulsing, but may just be my hearing.. With the spark plug getting wet with gas I feel like the injector is pulsing and spraying. Any suggestions would be great. I don’t know the hours on the unit offhand, but it has 600 miles on it. Thank you for your comments and advanced.

Link to comment
Share on other sites

On 3/5/2024 at 9:34 AM, Felderlostnspace said:

2016, Hisun 500 turns over great but Spark plug is firing when I turn the ignition key on. I’ve got good fuel pressure to the injector. Pulled plug out and it is wet with. gasoline. Air filter is clean. Turns over great just does not even try to pop or start.. I’ve checked off uses and they are good when I turn the key on I’m getting power to the injector.. I’m not hearing the injector pulsing, but may just be my hearing.. With the spark plug getting wet with gas I feel like the injector is pulsing and spraying. Any suggestions would be great. I don’t know the hours on the unit offhand, but it has 600 miles on it. Thank you for your comments and advanced.

Hey Buddy 

I would start with checking the valves and timing. 
good luck and let me know.

Don

Link to comment
Share on other sites

ICE requires 3 things fuel/air mix, Compression, and Spark.  ECM is doing its thing (+12 at both inputs and dual GND(s) AND pick up coil timing pulse) and fuel injector pulsing fuel.......wet plugs.  

CORRECT fuel/air mixture.  Some of the Hisun engines have a "spit" fuel injector which I believe to have been the 2 hole......find new 3 holers to get fuel/air mix to the magic 14:1 ratio.

DO a compression test....low compression can be due to:

!.  Rings worn and scoured (fuel wash down of oil) cylinder wall.  Some oil squirt in the spark plug hole will help seal rings and raise compression.

2.  Old engine (sitter???) carbon flake  gets under and/or between the valve and valve seat....usually the Exhaust....will have excessive valve clearance if not adjusted after carbon capture.  Low compression but no real danger to valve.  Multi-cyl engine, the running cyl(s) will drag along the dead cyl and then do a hot gas jet cut to the valve face.  V cut notch.

3.  Worn chain/weak tensioner....gives valve timing JUMPED.  Pull lid and TDC the crank and check timing marks.  Off a few teeth, poor run or not at all.  Way off and the piston has a late night date with one of the valves.....bent valve cannot close....no compression...no run.

T/S as follows:    Do the above checks.

1, Remove the air filter to TB plumbing......free unrestricted air flow and no possibility of gas fumes from air filter and air filter box.

2.  Disconnect the fuel pump connector under pass seat.......no more injector dump fuel.

3.  Dry plugs or better yet new spark plugs.  Can always use old as spares.

4.  Blow shop air into plug hole to dry the cylinder out........drop in the new plug.

5.  Starter fluid is now the only source of fuel......carefully give a squirt while cranking over engine......IF lights off, give several semi-auto squirts for a longer run.

6.  Engine is OK.  Reconnect the air box plumbing.  Remove air box lid and be sure air filter is clean and not slop oil soaked.

7.  Feed the air filter a 1 sec squirt on the filter body.  Restarts and with say a now 5 sec. run and die.

8.  Reconnect the fuel pump connector.  Back to stock.  should start and run if fuel system is OK.  If it goes back to it's old ways, injector is a spitter OR

9. Other inputs to ECM is making a rich mixture:  IAT-----open and the ECM thinks the air temperature is at the South Pole.

                                                                           MAP combo sensor.......engine load "signal" located in the intake plumbing at the throttle body.  It also determined the

                                                                           actual fuel delivery above the internal ECM map and dumps extra fuel....just lick the IAT functions as a "CHOKE".

May the T/S Genie be with you     BEN

Link to comment
Share on other sites

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

  • Similar Topics

    • By Randyh79
      Is there a way to adjust the brightness of the dash light on aHisun 750 sector?
    • By great8redsfan
      Okay folks. I have a low power issue. Been like this for a few years. Place I work at bought 3 and all have lost most of the pulling power.  They gave them away after local shop worked on one for 3 months and it had great power for about 1 month and then crap. They replaced throttle body, fuel injector, spark plug and IAC motor. Seat belt switches have wires cut and left open so no seat belt warning light anymore. It revs to 6k rpm in neutral but when put in gear and take off in low it just doesn’t seem to want to go anymore. Running 93 octane fuel with Stabil.  Any ideas greatly appreciated. I dont have a scan tool but no codes on dash. If held to floor it pops a little and runs almost 5K rpm but if I let off pedal about an inch it smoothed out and revs up to 6k rpm. 
    • By russnropes
      For the life of me I cannot find the directions on how to change the display to the standard for the USA - MPH. Not sure why Tractor Supply didn't do it before I bought it but it is what it is. Does anyone have the instructions to do this. I have the 2023 T Boss 550 just to be clear.
    • By Randyh79
      Does anyone know how to adjust the headlights on a 2024 Hisun sector /Bad Boy Bandit 750? The high beams are where the low beams ought to be.
      Thanks Randy
    • By Jon C
      Hello to anyone who reads this. I am Jon and I own J&M Outdoor Power, a very small, small engine repair shop. I was approached by Coleman about 6 months ago to become one of their Warranty Centers.
      I recently received 3 different UT400's and a UT500 all with similar issues. These units range from 2 months to 2 years old. Customers state that the unit(s) was/were running fine, then heard a pop and a loss of power, two would no longer start. The two that would run would not achieve normal operating speed (around 20mph I would say) without redlining the RPMs. I quickly found that the Valve lash on each unit had become too large on some(both intake and exhaust) and too tight on one(just intake). 
      After setting the gaps to .005(I found multiple different people suggesting bigger and smaller gaps, but no definitive Coleman Spec number yet) every unit starts, runs, and achieves top speed without issue.
      I don't know how many others have come across these issues, and I wanted to get something out on the web for others in the same predicament. 
      Please let me know if you have had similar issues.
      Edit: I realize that this will not be a fix all solution for this issue, as the oil level and condition should be verified before moving to the valves. Many times improper oil conditions will cause valve lash to change. These units all have good oil and proper oil changes.
×
×
  • Create New...