Quantcast
Jump to content

mixfixdave

Members
  • Content Count

    34
  • Joined

  • Last visited

  • Days Won

    1

Everything posted by mixfixdave

  1. I had been wanting to install power steering on my T4 for years so I went to the salvage yard last weekend and bought a complete column (minus airbag) out of a 2009 Nissan Versa for $125 with the ECU. It was a fairly simple install. The long shaft that fits to the Joyner steering rack actually fit perfectly into the Nissan column. Had to weld up a U joint on the Nissan column to make it a straight shaft and fab up one simple bracket. Connect power and ground plus a switched 12v and now I can steer with one hand!
  2. mixfixdave

    Joyner Trooper Power Steering

    More pics of the power steering setup...works great!
  3. mixfixdave

    Joyner Trooper Power Steering

    I wouldn’t deal with SB...he is always a pain in the ass for some reason the few times that I have ordered parts from him and everyone on the forum that deals with SB reports problems receiving parts or just getting ripped off completely. I will post some better pics as soon as I can, but I can tell you that the Nissan Versa column was simple to remove in the junk yard and the only additional parts I needed for installation on the Joyner was a 6” piece of 1/2” angle and 18” of heavy wire to run for power from the winch 12VDC connections. Oh, and I did have to weld up a U joint that was part of the Nissan linkage, but it was easy!
  4. mixfixdave

    No BS info request

    I’ve had pretty good luck with my 2009 T4. I bought it with 1300 miles about 6 years ago. I replaced the fuel filter and treated the electrical connections with some dielectric grease...Replaced the starter also at around 3500 miles. Had to reinforce the weak rear trailing arms and had to update the differential ring gear bolts, but it’s still running fine after 6000 miles. No engine or transmission problems. And it’s pretty simple to work on. Parts can be had from Casey Ye or Joynerusa.com. Oh, I’ve replaced the wheel bearings also. The Joyner Trooper has never left me stranded on the trail, in fact, I have rescued the razor guys with broken axles on more than one occasion!
  5. mixfixdave

    2009 Joyner trooper oil filter replacement??

    These should fit... Oil filter. Fram PH4967 Napa 1394 wix5194
  6. mixfixdave

    2009 Joyner trooper fueling problem

    If it eventually starts and runs well, I don’t think it is injectors...
  7. mixfixdave

    Joyner Parts

    Agreed...Casey Ye is the best!
  8. mixfixdave

    2009 Joyner trooper fueling problem

    Rock on...the Joyner is awesome. Can’t tell you the times I have hauled one of the Polaris guys back to get their trailer because of a broken axle. My buddies call it the family truckster! Just took a short ride about town and along the railroad trail here in Tennessee...have tags on mine.
  9. mixfixdave

    2009 Joyner trooper fueling problem

    Rock on...
  10. mixfixdave

    2009 Joyner trooper fueling problem

    Replace the fuel filter behind the gas tank. Mine was partially stopped up after 1000 miles, but the replacement has been good for the last 4000 miles...I got one at autozone that worked.
  11. mixfixdave

    2009 Joyner trooper starting problems

    I remember modifying that starter circuit on my Joyner years ago. Seems that the wiring from the key switch to the starter solenoid is not adequate to carry the current required to activate the solenoid, so I wired it to an external 12vdc relay that I placed near the starter. Next I ran wires from the battery which is close for the relay to supply voltage to starter solenoid.
  12. mixfixdave

    2009 Joyner trooper starting problems

    Hmmm...sounds like a bad starter.
  13. mixfixdave

    2009 Joyner trooper starting problems

    No start relay, just a 12v switched wire from the key switch to the starter solenoid small terminal. The solenoid (small round cylinder on the starter motor) is the starter relay.
  14. mixfixdave

    2009 Joyner trooper starting problems

    Should have 12v at this terminal when you engage the start position with the key.
  15. mixfixdave

    2009 Joyner trooper starting problems

    Pic of the original Joyner starter and the ID sticker from the new replacement starter that I ordered years ago.
  16. mixfixdave

    2009 Joyner trooper starting problems

    Had a loose wire to my starter solenoid once also. To test the starter, just short across the large terminals with a screwdriver. It’ll spark a bit, but if the starter is good, the engine will crank...use a old screwdriver.
  17. mixfixdave

    2009 Joyner trooper starting problems

    Had to replace the starter on mine once...here is the fuse box layout on my 09 trooperT4
  18. mixfixdave

    1100cc sand viper 2007

    Here is a snapshot from trooper manual...page 58. And front fuses...
  19. mixfixdave

    1100cc sand viper 2007

    Electrical connections. Check the rear fuse area...mine has had several faulty electrical connections there. Fuel pump fuse is there also.
  20. Got the steering wheel up a little higher also.
  21. This setup works great on my T4...
  22. Try Casey Ye... [email protected] I have ordered axle shafts and a few other parts from him for my 2009 T4. You have to pay with PayPal after you receive an invoice, but I have had no trouble. Also try Jounerusa...
  23. mixfixdave

    Silver Bullet Motorsports Legit or Not?

    Maybe that’ll motivate Rich to get Petethedog some parts in the mail!
  24. mixfixdave

    Silver Bullet Motorsports Legit or Not?

    And the guys at Joyner-USA.com are great... ‭(480) 882-9612‬.


×