Quantcast
Jump to content


Turbo

plumber

By plumber
in Joyner UTV SxS Forum

 Share

Recommended Posts

plumber Proficient

plumber

Posted
Posted

I been think about a turbo for my trooper I have a couple of question.On the fuel management they have 12 :1, 8:1, 6:1, 4:1 which one do you used.Do you have to still used your catalytic converter and your two 02 sensor.Does anybody know the diameter of the exhaust manifold is.

Randy Explorer

Randy

Posted
Posted

I can't help you on the tech specs but I can say that putting a turbo on my Trooper 2 yrs ago was the best single modification I have done. The improvement in drivability is staggering. My system was installed by Scott at Unleashed Motorsports in Cottonwood, AZ. I don't know if he is still up there or not. The catalytic converter and O2 sensors are all stock.

Randy

Guest Lenny

Guest Lenny

Posted
Posted

I been think about a turbo for my trooper I have a couple of question.On the fuel management they have 12 :1, 8:1, 6:1, 4:1 which one do you used.Do you have to still used your catalytic converter and your two 02 sensor.Does anybody know the diameter of the exhaust manifold is.

Scott in AZ uses 12:1 on his turbos. He also uses 2 fuell pumps to get the fuel pressure up 130-140 pounds. I have a Vortech fuel management valve that I am no longer using. It's nearly new. Also have the kit for changing the fuel ratios 12:1 10:1 8:1 6:1 4:1. I'll sell it for $125 with the kit if your interested.

Lenny

CrawlnT2 Enthusiast

CrawlnT2

Posted
Posted

I can't help you on the tech specs but I can say that putting a turbo on my Trooper 2 yrs ago was the best single modification I have done. The improvement in drivability is staggering. My system was installed by Scott at Unleashed Motorsports in Cottonwood, AZ. I don't know if he is still up there or not. The catalytic converter and O2 sensors are all stock.

Randy

Do you know what kind of power you put down to the wheels before and after the turbo? Has it been dyno'd? Do you think it added power lets say lower than 2500 rpms?

Randy Explorer

Randy

Posted
Posted

Do you know what kind of power you put down to the wheels before and after the turbo? Has it been dyno'd? Do you think it added power lets say lower than 2500 rpms?

No dyno info.

I can tell you that because of the close gearing of the transmission, there never seems to be a situation where boost is unavailable. I can feel and hear the turbo at lower RPM's, but the boost guage is around 0, so it does not seem to measure any output until around 2200 - 2500 rpm.

In fact, I dialed it down from the 10lbs I was getting to around 7lbs so that on long grades/hills (like Oldsmobile at Glamis) I could stay in the throttle. I was haveing to feather it at 10lbs because it would try to spin through the rev limiter (6000rpm) too quickly.

The best part is I do not have to concern myself so much with weight. I can carry the spare, use Maxxis Bighorn tires in all conditions, even deep sand at Glamis, bring my wife and dog, etc, etc. Just more enjoyable all the way around. But I am not a racer, I am in it for the long haul. I use the power to get where I am going, not to see how fast I can go.

Randy

CrawlnT2 Enthusiast

CrawlnT2

Posted
Posted

No dyno info.

I can tell you that because of the close gearing of the transmission, there never seems to be a situation where boost is unavailable. I can feel and hear the turbo at lower RPM's, but the boost guage is around 0, so it does not seem to measure any output until around 2200 - 2500 rpm.

In fact, I dialed it down from the 10lbs I was getting to around 7lbs so that on long grades/hills (like Oldsmobile at Glamis) I could stay in the throttle. I was haveing to feather it at 10lbs because it would try to spin through the rev limiter (6000rpm) too quickly.

The best part is I do not have to concern myself so much with weight. I can carry the spare, use Maxxis Bighorn tires in all conditions, even deep sand at Glamis, bring my wife and dog, etc, etc. Just more enjoyable all the way around. But I am not a racer, I am in it for the long haul. I use the power to get where I am going, not to see how fast I can go.

Randy

Is 5th gear 1:1? Just to know for when I dyno mine?

2scoops Proficient

2scoops

Posted
Posted

No dyno info.

I can tell you that because of the close gearing of the transmission, there never seems to be a situation where boost is unavailable. I can feel and hear the turbo at lower RPM's, but the boost guage is around 0, so it does not seem to measure any output until around 2200 - 2500 rpm.

In fact, I dialed it down from the 10lbs I was getting to around 7lbs so that on long grades/hills (like Oldsmobile at Glamis) I could stay in the throttle. I was haveing to feather it at 10lbs because it would try to spin through the rev limiter (6000rpm) too quickly.

The best part is I do not have to concern myself so much with weight. I can carry the spare, use Maxxis Bighorn tires in all conditions, even deep sand at Glamis, bring my wife and dog, etc, etc. Just more enjoyable all the way around. But I am not a racer, I am in it for the long haul. I use the power to get where I am going, not to see how fast I can go.

Randy

Randy,

How has the powertrain held up with the turbo? Also, there is already cooling issues in stock form. Are those compounded with a turbo?

Thanks,

Paul

Randy Explorer

Randy

Posted
Posted

Randy,

How has the powertrain held up with the turbo? Also, there is already cooling issues in stock form. Are those compounded with a turbo?

Thanks,

Paul

I have never had any heating issue of any kind. When I thought I had heating issues when I first got the Trooper, it turned out to be the guage calibration. Since that was resolved, it stays right in line. I live in Phoenix and spend a lot of time in the desert so I would think I would push the heating issue as much as anyone.

I replaced 1 CV Axle (not sure it really needed it, but rebuilt left rear bearing and wanted to be conservative) and upgraded to the CV driveshaft. I always use 4wd to balance the load on the output shaft which I was told is a weak spot. But other than that, just normal upkeep and adjustment. I have over 2500 km on the buggy and probably more than 1500 km of that was after the Turbo install.

I am a pretty conservative driver, (my wife is usually with me to keep me in line), but I still get into situations where I use every bit of power/suspension that I have.

Randy

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

×
 Share
Go to topic listing


  • Similar Topics

    • Sammy
      2017 TW450 Kohler ECH440 runs out of fuel when running wide open.
      By Sammy
      Runs fine just putting around the yard. Get it out on the road and about a half miles it runs out of gas. Let it idle for a few minutes and it will run for another half mile and do it again. Replaced both fuel pumps and filter. Does anyone know if I can get rid of the factory fuel pump?
    • HISUN Sector 750 EPS Failu
      Is Your HISUN Loud?
      By HISUN Sector 750 EPS Failu
      "Mrs. Smith" doesn't like how loud our Sector 750 is.  On a HISUN forum someone said the same thing about his 750.  I haven't given it much thought because I've been more focused on stuff that has broken.
      So, I used my decibel meter to check ours out.  4000 RPM, Low gear, under 20 MPH . . . . 97 decibels.  That's above most ordinances, even state boat noise limits.
      AI Overview Ninety-seven (97) decibels is considered very loud and dangerous to hearing with prolonged exposure, roughly equivalent to a newspaper press, a loud nightclub, or a snowmobile. At this level, damage can occur after just 30 minutes, necessitating hearing protection
    • Jeff freeman
      Utv wont start and broken fuel injection wire
      By Jeff freeman
      I have a Coleman 550.  Was having problems to start with where it would start and then shut off after a couple tries. It would take off and be good. It then got to a point where it would not start at all. I replaced the fuel injection twice the second time I replaced it I noticed a mouse or something had chewed one of the wires that connect the electrical to the fuel injector. . So two-part question first does anybody have a part number for that wire harness?  Second, any other ideas after I fix the wire harness permanently on what could keep it from starting I have gas flow up to the fuel injector.


    • Kierobi
      MSU 500 Fuel Pump Ground
      By Kierobi
      Have a MSU 500 that we got from my wife's uncle a while back. We've had it running and hauling around the property but it stopped a few months ago after what I thought was running out of gas and I'm just getting to looking into it. 
      Had fuel to the injector but nothing coming out the injector so swapped with new injector and installed inline filter in the supply hose from fuel pump. Tried again and still nothing but noticed this time that I can't hear the fuel pump priming. 
      Pulled off the electrical connection and I'm getting 12V to the fuel pump but it won't run. Put it on a test bench and got it to run so put test lamp between +ve and -ve terminals on the connector and nothing. Checked against the passenger seat securing post and get a light. 
      Tried chasing the wire back and think that the ground is through the ECU but not 100% sure. Can someone confirm for me? And if it is through the ECU, is the ECU just grounded against the frame or is it wired through to the battery?
      Thanks in advance and hope this all make sense!
    • RBonds007
      2019 Cub Cadet Challenger 400, trailer to transport the Challenger, and new, never used winch for sale
      By RBonds007
      I bought this SxS brand new.  A couple of years after I bought it, I became disabled.  Thus it has only 47 miles and around 16 hours of use.  I have no need to keep the SxS.  I am in Foley, Alabama.  It is very hard for me to get in out of the Challenger.  I would like to sell the set, 2019 Challenger 400, trailer and uninstalled winch (this was bought brand new as well, someone was supposed to help this newbie install and we never got around to doing this). I want  $6500 for the whole set OBO (Serious offers only).











UTV FORUMS

MORE SECTIONS

FOLLOW US ON

GET IN TOUCH

  • Automotive Webmaster
×
×
  • Create New...