Quantcast
Jump to content

Recommended Posts



Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now

  • Similar Forum Topics

    • 2016 challenger 700 Rattle noise

      2016 cub cadet challenger 700. Anyone else experiencing a rattling noise, sounds like it’s about center of the utv and only does it when it is coasting. Anytime the gas is pressed it will not do it. 

      By WTraywick, in Cub Cadet UTV SxS Forum

      • 1 reply
      • 208 views
    • Hisun 750 crew 2016

      I have a 2016 750 crew (it is a Cub Cadet but same machine). It has 108 hours, 49 miles. Basically new, but I got it used with 22 miles on it. The guy said it was too big, and that he wanted a RZR. It ran great for a little over a year. It then developed a rough idle and won't wind up to get past about 20 mph in high range. I have tried countless things, and I keep coming back to overfueling. It doesn' seem to be throwing a code.  I have done the following... Spark plug (multiple times) Check, clean air filter  Sprayed brake clean around intake while running (to be sure it isn' sucking air). Checked valve adjustment Replaced fuel pump assy., after breaking it trying to remove to check in tank filter. Checked wiring and connections Checked/cleaned spark arrestor screen Replaced fuel, trying different octane.  Checked compression. Compression should be 1200 kpa,  mine was between 700 and 800 kpa.  Also noticed oil had been increasing and is now milky looking. I figured gas in oil due to overfueling. Dad said milky or foamy meant coolant in oil so we figured blown head gasket. So, we put a new head gasket on it. Old one didn't look blown. Valves were tight like new, could still see cross hatch marks in cylinder wall (like new as it IS still new!) Put it all back together, torqued bolts properly etc... no change. Still runs poorly, compression still low! I don't think it is a compression issue. We pulled the rocker cover back off to check out the automatic compression release that we had noticed on the timing chain  sproket on the end of the camshaft. It seems to be working properly. Then a lightbulb went off. "Automatic compression release" appears to slightly open an exhaust valve... when?... while cranking engine to start. There is no way that we're going to get 1200 kpa compression (unless I were to back that exhaust valve way off)! I may try that when I re-install the rocker cover.   Anyway, I'm pretty convinced that it is fuel in the oil, and that it is over fueling like I originally suspected. But how do I know the cause?? Book says over fueling could be caused by Air Pressure sensor, o2 sensor, Solar Term door position fault, or ECU program error or damage. Those are some pricey parts.  Any input??  

      By Budmanbiker, in Hisun UTV SxS Forum

        
      • 9 replies
      • 1,169 views
    • 2012 Polaris RZR800

      2012 Polaris RZR800 On Ebay https://www.ebay.com/itm/Polaris-RZR800-4-Seater/323630188376?

      By johnpeter, in UTV Off-Road Classifieds - Buy & Sell

        
      • 0 replies
      • 199 views
    • 2014 Polaris RZR

      2014 Polaris RZR On Ebay https://www.ebay.com/itm/2014-Polaris-RZR-170/323617600617?

      By johnpeter, in UTV Off-Road Classifieds - Buy & Sell

        
      • 0 replies
      • 106 views
  • Similar Tagged Content

    • By johnpeter
      2012 Polaris RZR800 On Ebay
      https://www.ebay.com/itm/Polaris-RZR800-4-Seater/323630188376?

    • By johnpeter
      2014 Polaris RZR On Ebay
      https://www.ebay.com/itm/2014-Polaris-RZR-170/323617600617?

    • By johnpeter
      2015 Polaris RZR On Ebay
      https://www.ebay.com/itm/2015-Polaris-RZR-S-900-EPS-SXS-Side-by-Side-ATV-UTV-Razor-1k-Miles-Clean-Unit/382527959951?
       

    • By johnpeter
      2016 Polaris RZR  On Ebay
      https://www.ebay.com/itm/2016-Polaris-RZR-170/202382224119?
       


    • By Khuisrzr
      I am looking for a gps system for my 2016 Polaris 1000 Turbo 4 and hoping for some help. I don't know much about gps systems so I'm at a loss on where to start.
      We ride in Michigan's upper peninsula which has endless unmarked or poorly marked trails. I would like to be able to track my ride and use it to reference the general direction to get back.
      Does anyone have any suggestions on a product that would do what I need. Phone service is very poor and I would prefer a seperate gps unit.
      I have looked into Trail Tech gps but they don't make a model for the Polaris rzr. They do have a generic one but wondering if anyone has used it. http://www.trailtech.net/digital-gauges/voyager-moto-gps/912-705
      Thanks for your help! Krista


×