Quantcast
Jump to content

Lube Rack& pion steering


flatbed

Recommended Posts

Notice that my steering was getting stiff and hard to turn so i pulled the cover of the rack & pion (6 allen head screws and you have to loosen the small screws to get the boots out of the way). Once it was off i could see the rack was very dry and starting to gull the cover. Once the cover is off you can pull the rack up and out with it still hooked to the tie-rods, You will see the gear in the slot. I spread some grease on the gear and in the slot, also some grease on the rack. You can see i also put zert fitting on the cover so i can grease it without taking it apart . If you do not want to do this you need to aleast pull the boots back so you can get some grease on the rack. This is something everyone that has a trooper needs to do.

2149669010104282158kQHhWl_th.jpg 2734587900104282158jxUyTy_th.jpg 2672825280104282158kyHmpz_th.jpg 2185755440104282158mudMiZ_th.jpg

Link to comment
Share on other sites

Notice that my steering was getting stiff and hard to turn so i pulled the cover of the rack & pion (6 allen head screws and you have to loosen the small screws to get the boots out of the way). Once it was off i could see the rack was very dry and starting to gull the cover. Once the cover is off you can pull the rack up and out with it still hooked to the tie-rods, You will see the gear in the slot. I spread some grease on the gear and in the slot, also some grease on the rack. You can see i also put zert fitting on the cover so i can grease it without taking it apart . If you do not want to do this you need to aleast pull the boots back so you can get some grease on the rack. This is something everyone that has a trooper needs to do.

Very good advice, I have had these freeze up in the winter from getting water inside.

I always keep them packed with grease.

Link to comment
Share on other sites

Good advise. I have done mine a bit back. My steering rack was quite sloopy and caused not only extra slop in the steering but it clunked fairly loud when in rougher stuff. To fix the problem, I made up a new top plate. You can see what I did at:

http://cgi.ebay.com/ebaymotors/Joyner-Troo...sspagenameZWD1V

Forgive me, this isn't an advertisement but rather sharing ideas that hopefully help our machines. I feel a little stupid for not putting the greese fittig on it as flatbed sujested. I know better but I guess it's old age creeping in. I'll be adding the fitting shortly.

Lenny

Link to comment
Share on other sites

Lenny, I thought of putting a teflon wear plate in, but i thought i would still have to grease it because of the gear. The rack is going to want to wear on the corners, top and bottom. Nice piece

flatbed, I'm not sure you would want teflon. It is slicker but I beleive on the softy side. UHMW polyethylene is probably a better choice as it ireal tuff and still quite slippery. The advantage of poly or teflon for that matter is that grit will embed into it rather than wear parts away. With the boots, you shouldn't be getting dirt contamination. On my machines, I always used greese with poly. I'm not sure it is really necessary but I like to think it's a little better when greesed unless it's exposed to contamination.

Lenny

Link to comment
Share on other sites

  • 3 months later...
Guest Lenny

When I took my steering rack off today to install an electric assisted one, I discovered that the stock rack does have a greese fitting on it from the factory. It's in the middle on the bottom side where we can't find it unless we stand on lour head. It would be nice if JoynerUSA would follow these post. They could have told us there was a greese fitting and where to look for it.

Lenny

Link to comment
Share on other sites

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

  • Similar Topics

    • By great8redsfan
      Okay folks. I have a low power issue. Been like this for a few years. Place I work at bought 3 and all have lost most of the pulling power.  They gave them away after local shop worked on one for 3 months and it had great power for about 1 month and then crap. They replaced throttle body, fuel injector, spark plug and IAC motor. Seat belt switches have wires cut and left open so no seat belt warning light anymore. It revs to 6k rpm in neutral but when put in gear and take off in low it just doesn’t seem to want to go anymore. Running 93 octane fuel with Stabil.  Any ideas greatly appreciated. I dont have a scan tool but no codes on dash. If held to floor it pops a little and runs almost 5K rpm but if I let off pedal about an inch it smoothed out and revs up to 6k rpm. 
    • By Xov
      Just received delivery of a 2024 AMP Pro.  Thought I'd start a thread with my impressions as I use it and learn more.  There doesn't seem to be a whole lot of real-world usage information out there on this model.  Hope this will help others as they research.
      Intended Use Cases
      Fire mitigation / slash removal from a 5 acre forested and well-gamble-oaked property.  The previous owners thought as much about fire mitigation as I do about fashion: not much. Snow removal Stump pulling General hauling (rock, lumber, etc.) Weimaraner energy depletion.  Wasn't an original use case, but a nice added bonus.  Experiences So Far
      Wasn't impressed that two of the bumpers on the underside of the bed where it sits upon the frame were missing.  The metal on metal contact has damaged the powder coating and the frame.  I expect a little better QC.
      I've only put a few hours on it, so not a ton to report on usage.  It isn't quiet; it's silent.  I can't even detect an electric note from the motor. I removed (and subsequently replaced) the motor cover noticed that the motor is German and made by Schambuller.  The motor controller is Italian and made by Dana TM4.  Given the operating specs of both I found on the web, I suspect both are higher quality than the previous Navitas (which is supposed to be decent).  The motor is rated at 25 hp and 71.5 lb-ft of torque.  It feels very powerful.  All the torque is delivered instantly, if desired.
      The bed is huge and has an electric dump as standard.  Great feature but would like it to go up a bit more.  Probably not feasible from an engineering perspective, but I want and I need ;).
      Power steering is nice, but vague.  Probably common to many UTVs, but I am accustomed to more direct results from input.  Plan early and plan often.
      In our first full day of usage, we hauled about 1/2 as much slash as the entire rest of the year when I was doing it by hand cart.  I may get fatter, but I'll also get more done.  After a few days of usage, the battery meter has gone down by 1/10th. 
      Until next time...


    • By packersfan
      I have a hisun 500 got from a auction and when turning a corner left or right it's a two hand job then when you left go snaps back.any help on what to look at would be appreciated.
      Also blows blue smoke until she gets warm then it's ok 
    • By NicholasNWM09
      Hello Everyone,
      COOL NEW Product Alert! 
      A company called NEW Wire Marine or NEW Wire has Badass custom panels for UTV, Buggy/Hunting trucks. From Fully wired switch panels with laser etched rockers with backlights in 5 different colors, to just parts like voltmeters, phone, USB and 12 v chargers. Rockers can be printed, or custom laser etched rockers and they even have sleek labeled pushbuttons. They are a first-class company with a great knowledgeable staff and outstanding customer service. Switches are based on 12v or 24v circuits and they also have marine grade wire and connectors, which is perfect for waterproofing your system!
      Go check them out!
      Check out the websites : https://newwiremarine.com/ and https://rockerswitchpros.com
       
       
       
       
    • By NicholasNWM09
      Hello Everyone, COOL NEW Product Alert! A company called NEW Wire Marine or NEW Wire has Badass custom panels for UTV, Buggy/Hunting trucks. From Fully wired switch panels with laser etched rockers with backlights in 5 different colors, to just parts like voltmeters, phone, USB and 12 v chargers. Rockers can be printed, or custom laser etched rockers and they even have sleek labeled pushbuttons. They are a first-class company with a great knowledgeable staff and outstanding customer service. Switches are based on 12v or 24v circuits and they also have marine grade wire and connectors, which is perfect for waterproofing your system! Go check them out!!!Honda - xxxx - UTV Pioneer - xx'.pdf
×
×
  • Create New...