Quantcast
Jump to content

MU500 stops running at idle


dmorga11

Recommended Posts

Have an MU500, I believe it is a 2014.  It just started not wanting to start, so I changed the battery since it was about time to need a new one.  Now it starts without any problem, but will shut off in an idle.  If I give it throttle it will keep running, though it does sound a little rough, but once it gets to idle speed it shuts off again.  The only way to keep it running is to keep the gas pressed.  Any idea what might be causing this?  

Link to comment
Share on other sites

Digital dash? Codes? Check engine light?

Kinda same issue on 2021 axis 500. Wouldn't idle on its own, only happened that one ride so far. Had code 201 flash on dash. Called tech and he said to change filter and spark plug. Haven't done it yet. Kinda busy.

1. Check injector wiring.

2 Check all wiring.

3. Check ail filter. Could be choking itself out at idle.

Link to comment
Share on other sites

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

  • Similar Topics

    • By malenurse13
      We just bought a used 2017 American Landmaster TW450. No hour meter that I can find, so not sure exactly how much it has been used. 
      The first 2 days we had it, the starter was a little sketchy, but it started after 2-3 tries. Sometimes when turning the key, we would hear a loud metal "clink" sound. Like the starter made contact, but didn't have enough power to turn. 
      THIS MORNING... Turning the key, we hear a single click sound. That's it. Even with a new battery, the starter is still doing the same thing. Both batteries (old and new) were reading 12.8 volts on volt meter. So I'm wondering what else could be going on? Any ideas on what to look for would be greatly appreciated...
      Thank you!
    • By SteveMO
      Folks:

      I live on 11 acres that demands a bit of maintenance, and co-own a large farm a couple of hours away that I hunt on (professionals do the farming).   My mowing/brush control/trail maintenance duties are handled by a 57" rough cut mower (Kunz brand), and I also drag logs and pull sprayers and seeders for food plots and such.
      I've been using a  pair of ATV's for decades to handle this work - a 750 for when I need real power (or need both machines at the same time when I have help) and a 500 cc with fixed rear axle for most duties.

      Some of the places I need to work are VERY rough, and very three-dimensional, with steep ups and downs and some side-hilling I've learned the hard way not to try with my independent rear suspension 750, but handle with ease with my fixed rear suspension 500.

      I've decided I want to sell the 750 and replace it with a UTV that I hope to use as my main workhorse.  If anyone makes a working UTV that fits my specs that's what I'm gonna do.  This is an all-work machine, I don't do any recreational riding so don't care about things like top speed.

      So looking for advice on what models might handle what I'm looking for:

      Gotta have:
      2 passenger (1 row)
      selectable 4wd
      Power steering
      Selectable gearing (not CVT)
      Power-assisted dump bed
      Engine cooling adequate for all-day slow-speed work in the summertime.  Like towing a 700lb mower at 4mph all day in 100° weather)
      Beefy tow rating, including tonque weight.  Nobody ever mentions tongue weight because that exposes how crappy independent rear suspension is for towing safely in rough terrain.

      Really want:
      Selectable locking diff
      Fixed rear axle (Isolates tongue weight from rear suspension.  Holds more stable & consistent center of gravity than IRS over side-slopes and other complex terrain, and keeps geometry and suspension response consistent over wide range of tongue-weight of towed loads)
      Slow speed cruise control (Factory option or aftermarket, covering at least 4mph - 10mph. For calibrated spraying and controlled mowing speed.
      Muffler designed for quiet operation for comfortable all-day use, and to minimize disturbance for getting to hunting grounds.  Not concerned about normal motor noise, but don't want something specifically piped to "sound fun".

      Any advice on brands or models I'm most likely to have luck with?
       
    • By Greg Kilgore
      We all know summer is hot inside the cabs of our SXS. So I've rigged up a couple of fans to help cool down the cab.
       
      I didn't want to drill the fan's "support rails" into the ROPS (Roll Over Protection System), aka roll bars. So I used water clamps to hold them in place. 
       
      I just need to replace the wires I ran with bigger gauge. Then finish the wiring to switches, relays, and battery. But the hardest part. The actual mounting of the fans is complete. Also just in case anyone plans on doing this. I may have to only use 1 fan in the middle instead on 2. Due the the draw on the battery.
      The fans are 12", 12V 80W. So I'm figured they were 6.7 amps apiece. Used the WAVe formula to get unknown values Watts=Amps*Volts then solve for unknown. I know the watts and volts from sticker on fan. So just used above formula to get amps. So a 7 amp fuse should be OK and a 10 amp fuse will be good. 
      So pulling 14 amps from the battery all day may be too much for the charging system to keep up with. And I haven't even installed the radio yet. So I will have to test and let you know.
       
      See pics below.

    • By Chad comeaux
      I have a 2014 polaris ranger 570
       As soon as you turn on the key fuel starts to come out the exhaust and air filter. I have replaced the fuel injector but that did not help. If you try to start fuel stars to poor out the exhaust.  Any help would be appreciated. 
    • By Sommer Wildes
      TLDR (too long didn't read) in blue for quick scanning
      Hey all! I'm new to the Side-by-side/UTV world. We own a smallish farm and decided to go with the 2021 Tracker 800LE Crew. We like the seating and the ride is smooth. However as a newbie I have some questions that maybe some of you longtime side-by-side/UTV owners can help with. We're still in the "break-in" period and it seems that after 30 min or less of driving the dash area gets super hot. You can feel the heat waves coming off the floorboard by your feet and my phone sitting in the little hole (where a radio might go) felt like I left it in the hot sun for too long. The glovebox was also way too hot. 
       
      So the question is, is this normal, or should I start checking engine coolant and filters? We literal have had it a day. I have read forums and looked up info and can't find anyone mentioning this issue. I just don't want to burn the thing up before we've even put it through it's paces ya know!
       
      Thanks for any help!
  • Gallery Images

×
×
  • Create New...