Quantcast
Jump to content

2002 - Mule 3010 - Front Differential fluid fill location?


Recommended Posts

Where oh where is the front differential fluid fill location?? I found the drain but cannot find the fill plug! The manual shows a plug just in front of the differential vent tube but there is NOT one there on my Mule!

 

Don't want to drain until I know where/how to fill it. I know it takes very little fluid but how do you get it in the frick'n differential? Been on the lift 2 weeks now!!!

DSCN2903.JPG

Link to comment
Share on other sites

Gotta be on the front side, at or near the top. Mine is an 05, 3010. And it's clearly visible from the front, when you bend over just enough to see the diff. 

  Maybe yours just doesn't look like that's what it is. Like the trans. drain on my Honda. It just looks like another bolt. Good thing the factory labeled it with tiny letters. Shame they didn't do that in your case.

If you think a picture of mine might help, I'd be happy to go out and snap one. But mine is too obvious, there's no way anyone could miss it. So yours is likely different.

Link to comment
Share on other sites

Thanks Ken!...but I found it!

The SPECS show it being in a different place but I found it tucked tightly behind the front skid plate. I was confident that I was wasting my time pulling the skid plate because I felt I could see everything clearly enough but.......NO. Once I dropped the plate there it was looking just like a "fill plug"!! I wasted 3 days whining about it rather than grab a wrench and turn a few bolts!

 

Lesson learned! I filled the Engine oil today along with the Tranny...over filled both!!!!! Spent all afternoon messing with a syringe to suck the excess out.

 

I'll do the front diff tomorrow and NOT over fill it. It supposedly only takes 0.06 of a quart. I'm also using some "limited slip differential fluid" for my Corvette. Maybe that'll help with the 'ol "Mule Differential Chatter".

Thanks again,

DJ

DSCN3008.JPG

Link to comment
Share on other sites

4 minutes ago, Hillman said:

Thanks Ken!...but I found it!

The SPECS show it being in a different place but I found it tucked tightly behind the front skid plate. I was confident that I was wasting my time pulling the skid plate because I felt I could see everything clearly enough but.......NO. Once I dropped the plate there it was looking just like a "fill plug"!! I wasted 3 days whining about it rather than grab a wrench and turn a few bolts!

 

Lesson learned! I filled the Engine oil today along with the Tranny...over filled both!!!!! Spent all afternoon messing with a syringe to suck the excess out.

 

I'll do the front diff tomorrow and NOT over fill it. It supposedly only takes 0.06 of a quart. I'm also using some "limited slip differential fluid" for my Corvette. Maybe that'll help with the 'ol "Mule Differential Chatter".

Thanks again,

DJ

DSCN3008.JPG

Nice lift you have there!

I'm glad you found that plug, mine is tough to get to with the huge winch mount that's there. But I remember seeing that plug on the front of the diff. Hope I don't need to access it anytime soon. I'd probably come in from the top.

Hope that cures the problem you're having. Others have problems caused by driving on hard pack, with the vehicle in 4wd. That's definitely something to avoid. I'll occasionally exercise the front differential, by using a perfectly straight road, and not even a swerve. Put it in 4wd for a block or so. Since mine rarely sees any mud, or hills, I do this to keep the seals from drying out. I've heard others needing serious work to remedy problems caused by leaving it in 4wd on hard pack, or pavement. 

Don't know if you've got the torque specs, I'm sure they're the same as mine. Looks like 22ft lb.

20170728_183658.jpg

Link to comment
Share on other sites

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

  • Similar Topics

    • By Travis
      View File Kawasaki Mule 550,520,500 Complete service manual
      This is a complete service manual for the Kawasaki Mule 500,520 and 550 models.
      Topics  covered include Brakes, Steering, Electrical system, suspension and fuel system. As well as engine repair procedures and Transmission/Final Drive procedures.
       
      ********************************************************************************************************************************************************************************************
      If you need more information about the engine this manual linked below is chock full of information.
      Thanks goes to @cliffyk for getting these files all  into one PDF format for uploading.
      Submitter Travis Submitted 04/18/2021 Category Kawasaki  
    • By ETHIEL
      Spark plug keeps fouling. after 10-15 minutes of running any ideas what to look fore 
    • By AlaskaTrail
      Hi All,
      New to UTVs and recently accuired a ut400 from our local Alaska Commercial Co. and had a questions regarding the transmission fluid. I have had a squeeling noise, sounds like a teapot, that recently started after being driven for a few minutes. The manual says to change the fluid at 500 miles, so I was thinking maybe its just time for this to be changed. Other then that I cannot find any information regarding the type used. While reading through these forums, I seen someone put that the transmission is lubricated with the engine oil. Is this true? If not what should I be using and where can I find the information to change it out? Any input on this would be greatly appretiated!
      Thanks in advance
    • By LindaCall60
      Purchased a 2011 bighorn banchee. Needs motor work. Not sure what. Husband is mechanic but not computer savvy. So, is there a manual that will tell him how to tear this down?  We have down loaded a service manual, but he says it doesn't tell him what he is looking for. 
    • By strike250
      I have the factory service manual available for the Buck 400. Just send me a message with your email and I'll get it to you. Although there is no charge for this, it would be great if  you would visit my website where you could donate any amount to help do things like this with others who need it. Again, there is no charge for this manual, and no obligation to donate. But if you did, I would thank you for sure. Have fun on the trails. www.warriorsoffroad.com
       
      Matt

×
×
  • Create New...