Quantcast
Jump to content

Hisun utv wont start no elec on dash

Rick A

By Rick A
in Hisun UTV SxS Forum

 Share

Recommended Posts

  • 3 months later...
  • 4 weeks later...
candl Newbie

candl

Posted
Posted

2017 sector 550. This rig is new to me, second time using it went about 7 miles and when I turned it off it made a air escaping or winding noise and the electrical blinked then nothing. nothing. I do have a circuit probe and would love to be walked through troubleshooting thank you.

Link to comment
Share on other sites
candl Newbie

candl

Posted
Posted

I ordered a main relay fuse but it came with four wires instead of three. Haven't seen any of these with three wires like the original, but figure its like a replacement windsield wiper motor where you just have to figure it out and get a plug to match? Am I correct in that assessment?

Link to comment
Share on other sites
aefron88 Community Regular

aefron88

Posted
Posted

Ok so just to recap since yours isn't the original post:

You shut it off and it made an "air escaping or winding noise" and now it wont display anything or start correct? Lights don't work with the key on?

I'm trying to figure out what the noise might have been but blanking on anything.

Have you checked the battery voltage? Should be at least 11.8V.

From there I would open the fusebox (little black box with 4 screws holding the cover) check that all the fuses are getting the same as the batt voltage (check between the fuse terminal and the neg batt terminal). Then check that all fuses are intact and not blown.

 

Link to comment
Share on other sites

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

×
 Share
Go to topic listing

  • Similar Topics

    • didgeridoo
      Hisun Sector e1 Battery replacement: any tips?
      By didgeridoo
      Hello, All!  I've decided to replace the traction batteries in my 2018 Sector E1 with a 48V Lithium set. They may be expensive, but I figure the Discovery Dry Cell are, too. I am not looking for the max driving range, as I have never received near the brochured range to begin with, but a good mix of charge/ get work done/ charge is what I am expecting.
      I have settled on the 48V EAGL kit from bigbattery dot com. Each battery pack provides 30Ah. The kit ships with a charger, as well. The packs would be physically connected in parallel (using a busbar) to one another, maintaining the 48V voltage, but together would be able to provide the amp draw the buggy pulls when going up hill or towing a rake (rated 320 max continuous Amps). This is in comparison to the serial connection the eight 6V lead batteries. Each of the EAGL batteries looks to have its own BMS; am I correct in thinking I will have to use their included charger rather than (simply) changing the onboard charger to lithium mode? The chemistry of the pack is LiFe PO4, for what it's worth.  I haven't torn anything apart yet (to diagram), so  I am not sure how the dash will interpret the AMP draw, but the kit I am looking at includes a dash mounted charge indicator.
      If anyone has completed a similar conversion, do you have any tips? Specifically, how did you remove the original batteries, and how did you secure the new ones? I am guessing that almost any change from the stock batteries would involve at least some modifications. Any tips would be appreciated, especially things I may have failed to consider. Thanks!
    • rtate1050
      UTV Wheelchair
      By rtate1050
      I know that this may be a bit outside the forum , but has anyone had any experience with all terrain wheelchairs ? I live on 5 sandy acres in Florida and am currently wheelchair bound. I have a power wheelchair but it doesn't work very well on my property . I.m looking at one that has rubber treads like a tank . It's pretty expensive so I was wondering if anyone had any experience or knows anything about them before I pulled the trigger.
      I do have aa side-by-side but can't get in and out.
      Thanks , Rich
    • Randyh79
      Hisun Sector 750 – dash light adjustment
      By Randyh79
      Is there a way to adjust the brightness of the dash light on aHisun 750 sector?
    • malenurse13
      American Landmaster TW450 Won't Start!!
      By malenurse13
      We just bought a used 2017 American Landmaster TW450. No hour meter that I can find, so not sure exactly how much it has been used. 
      The first 2 days we had it, the starter was a little sketchy, but it started after 2-3 tries. Sometimes when turning the key, we would hear a loud metal "clink" sound. Like the starter made contact, but didn't have enough power to turn. 
      THIS MORNING... Turning the key, we hear a single click sound. That's it. Even with a new battery, the starter is still doing the same thing. Both batteries (old and new) were reading 12.8 volts on volt meter. So I'm wondering what else could be going on? Any ideas on what to look for would be greatly appreciated...
      Thank you!
    • Jay5
      Quiet utv
      By Jay5
      I’m looking for a quiet side by side for my wife and I. We will do some trail riding but nothing too extreme. We are more geared toward leisure riding since we are in our sixties. We go to Wyoming in the summer and have been looking at the Honda Pioneer 1000, can am defender.

UTV FORUMS

MORE SECTIONS

FOLLOW US ON

GET IN TOUCH

  • Automotive Webmaster
×
×
  • Create New...