Quantcast
Jump to content


Recommended Posts

Posted

So... I have just finished rebuilding the 500 (bought it with low compression).

The rebuild was successful runs great. But, I'm not circulating water. I've been trying to read through the forms to figure this out and I'm going through the process of trying to bleed or replace my water pump either way there is a hose barb. 

Posted

Most common cause of no circulation is an air lock.

You should not have to bleed the actual pump.

Should be bleeder near upper rad hose on engine.

Be sure to run it with rad cap OFF or you will never get rid of an air lock.

Also wouldnt hurt to test thermostat, keurig is hot enough to open it, pour a cup of hot water, no pod, drop in stat and watch it open. Sometimes takes 2 tries if cup and stat are cool.

Posted

The main trick is tilting the front end up.  Block the rear wheels and jack up the front end at least a foot.  A convenient ditch works well also.....rear wheels in a shallow ditch.  The head bleeder screw should be opened.  With the engine NOT running, almost fill the radiator (leave some air to avoid a mess) and burp (squeeze the lower hose line before the metal tube at the engine base passenger side floor area).  Watch the radiator and the the bleeder.  With the radiator "higher" than the head bleeder, the air should be bled and coolant dribble out.  Close the bleeder and refill radiator (your clue you displaced the air with coolant) and start the engine.  Burp more while running and if you get the circulation going the hoses will warm up.  More bubbles should surface at the radiator filler neck.  Shut off engine.  Open bleeder and release any air in the head.

The puke jug needs to be filled about an inch above the full cold line.  Use a shop towel as a "seal"and use an air nozzle to SLIGHTLY pressurize the puke tank removing the air from the tubing line to the radiator neck.  Then the radiator starts to overflow, a third hand can install the radiator cap.  Run the engine and determine the head and hoses are at the close to the same temperature (as in warming up) through out the system.  IR temp gun....fairly cheap now....can get real numbers.  Scan the radiator, hoses, cylinder and head.....if all close you are done.  Recheck fluids when done riding.  Recheck the bleeder and top off the puke jug as required.

  • Like 2
Posted

Nothing....weep hole for coolant to escape if the water pump seal fails.....don't end up in the engine oil.  Some brands use a small J hose that bugs nest and block off or mud will seal over....which is not good.

Posted

Other than what Ben1098 posted, you could try to take both radiator hoses disconnected from radiator. With front of machine raised. Pour antifreeze into one hose until it comes out the other.

OR with front raised, Disconnect the top hose. Leave bottom hose connected to radiator. Pour antifreeze into radiator until it comes out the top hose. Then reconnect the top hose.

Posted

problem is the air blocks the water passage on top of the head.. you gotta bleed it there and mine has bleed at waterpump. some air was trapped there too.. If air is in it, water will not circulate and it will overheat fast.

  • Thanks 1

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

  • Popular Now

  • Similar Topics

    • By rdc
      Hope I posted this in the right place. Looking for the left side shaft carrier where the rear bearings go for an 1100cc sand viper, I understand an 800 cc carrier will also work. I need the old style two bearing with the spacer in the middle, the new style with just the one wide bearing wont work. If anybody has one I'll buy it right away. my email is [email protected]
    • By Kierobi
      Have a MSU 500 that we got from my wife's uncle a while back. We've had it running and hauling around the property but it stopped a few months ago after what I thought was running out of gas and I'm just getting to looking into it. 
      Had fuel to the injector but nothing coming out the injector so swapped with new injector and installed inline filter in the supply hose from fuel pump. Tried again and still nothing but noticed this time that I can't hear the fuel pump priming. 
      Pulled off the electrical connection and I'm getting 12V to the fuel pump but it won't run. Put it on a test bench and got it to run so put test lamp between +ve and -ve terminals on the connector and nothing. Checked against the passenger seat securing post and get a light. 
      Tried chasing the wire back and think that the ground is through the ECU but not 100% sure. Can someone confirm for me? And if it is through the ECU, is the ECU just grounded against the frame or is it wired through to the battery?
      Thanks in advance and hope this all make sense!
    • By Hunterman22
      Can anyone please tell me or send a link as to how & where to hook up a code reader to my 2021 Hisun 500 Axis.  I have a 6 pin to a 18 pin  adaptor and the blue cord VAG KKL adaptor .Just not sure where or what to hook up to. Can I use your typical vehicle code reader or do I need to download something on a laptop or PC???
       
    • By Eman85
      Pulled fuel injector to see if I could clean it or if it's stuck open. Had a slide on clip that was really tough to get off. Don't see how the clip is supposed to lock into the plastic part that the injector slides into. Any videos or pics of injector replacement? 
    • By Rmillerdesigns
      Hello. I have a 2016 Massimo MSU 500. I was putting on a lightbar and i screwed up and didn't disconnect the battery so when i was taking of the positive cable to put on the power from the lightbar it sparked and now the utv has no power. I turn the key over and all i hear is a chirp. No lights or anything. Everything that comes from the battery to the jumper box up by the battery shows voltage but anything coming out does not such as to the winch or anything like that
×
×
  • Create New...