Quantcast
Jump to content

t2 cluch problems


LEE 73

Recommended Posts

I have seen mud packed into the pressure plate causing an issue like that, also check the linkage where the slave cyl is. Make sure that's not too tight

Thanks Jarrad i will try that i was in a lot of sticky mud.if my cluch is fried what do you recommend and how tuff is the job.thanks agin forthe help.

Link to comment
Share on other sites

Thanks Jarrad i will try that i was in a lot of sticky mud.if my cluch is fried what do you recommend and how tuff is the job.thanks agin forthe help.

The job is not that bad, just time consuming and a little frustrating depending on what approach you take. All in all should take about 5 hours worth of work to get the clutch in and out. I would not think of replacing it with such low mileage unless it is already burned up. When you get the tranny out check for the packed in mud in the bell housing and pressure plate, disassemble it and wash in brakeclean, it evaporates fast and leaves no residue. If the mud is the issue, then find a way to seal it up as best you can when going back together if you insist on playing in the mud. Also go ahead and drain the tranny and diff fluids and change those with a synthetic, I reccomend Royal Purple 75W-90, and find your vent lines for the diffs and tranny and extend them up if there is water in them. something as high or higher than your deepest water you plan on being in. I usually extend them up the cage to the top of the buggy. If you get it that deep then you have real issues that no amount of extending lines and snorkleing will help. :)

Jarrad

Link to comment
Share on other sites

Thanks guys Ipulled the moter today cluch fiber all balled up inside the bellhousing will post pics later after i load them ordered a newupgraded cluch from silverbullet today little pricey but hope this will be the last one i have to put in . dose any one have any ideas on a cluch alignment tool.

Link to comment
Share on other sites

post-904-0-13186400-1299040758_thumb.jpgpost-904-0-45848200-1299040777_thumb.jpg

Here are some better pictures.

Those shreaded clutch pieces reminds of a learning experience from my teen age days, AKA real screw up, My dad had a 6 cylinder chevy pick up with a 4 speed manual, 1st gear being granny or compound, but real low, max speed with engine revved was about 15 mph. One day, at the top of a hill, I put in first and held the clutch in and let it coast down the hill, planning on letting clutch to see if it would drag the rear wheels, at about 25 mph, every thing started shaking real bad. It tuned out that the clutch plate had slung apart. OOPS, sure glad I had an understanding dad.

Jeff

Link to comment
Share on other sites

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

  • Similar Topics

    • By Steve B
      My "R" light on the dash will not go out when I take the UTV out of reverse and put it into any other gear. Is this just the light switch issue or will this effect engine performance in the other gears?
    • By Nathon S.
      I have a Bennche 700 EFI Bighorn. I’ve recently been unable to get it to start. After a little troubleshooting I realized my fuel pump was not pumping fuel. This weekend I emptied the gas and replaced it with new. I replaced the fuel pump, fuel filter and fuel injector. I also replaced the battery, spark plug and made sure all my fuses and relays were good. I have confirmed that the float on the fuel pump is not obstructed. The UTV is about 12 years old and has less than 100 hours on it. It has not run in over a year.  Not sure whats going on?!? After doing a little reading I'm leaning towards it being an issue with the ECU or perhaps a faulty wire in the wiring harness. Anyone have any ideas on where to start looking or what I could be dealing with? Any help is appreciated, thanks in advance!
    • By REDfletching
      Spent today at a Honda dealership looking at their 520 side by side, then on the way home past our Lowes noticed they had several new UTVs on site, so we U-turned and ducked in there. We were impressed that all that came for $9,999 metal whole length skid plate, nice sized bed, roof, windshield, side mirrors, winch, upgrade looking tires… all of which would have added thousands of dollars to an already expensive Honda 520. Now Honda does have a great reputation from my trusted UTV experienced buddy, so it has that going for it.
    • By AlphaSerenity
      Hello,
      Before I invest $10k+ into a brand new UTV for the farm, I want to get my feet wet with a fixer upper and learn the mechanical side of things. I acquired a 2022 Hisun Axis 500 (Lowes-specific model) from an auction for $500. It has only 200 hours and 120 miles on the engine. It looks like the previous owner used it for ranch work and didn't drive it on trails, deep water/mud, or anything too crazy.
      While it runs and moves, it has some problems. It struggles to accelerate up any incline in high and low range and sometimes stalls when I let off of the throttle or change gears. When I apply throttle in neutral, it sounds like it is struggling for fuel/air and pops. When I decelerate, there is a grinding sound coming from the clutch, which I've read to be related to the one way bearing and is semi-common. The last thing I've observed is sometimes the speedometer display sometimes will show a much higher value for a few seconds after barely touching the throttle. Based on the documentation, if a problem is detected from the sensors, the instrument panel display should have an error code rendered on the screen in place of the time, but this isn't happening. Here is a video showing some of these issues (engine is exposed with console removed):
      https://www.youtube.com/watch?v=FFAkO5TaGps
       
      Here is another video of the clutches in action:
       
      I've done some research, but information on this specific unit and sister units is limited. There does seem to be transmission and clutch issues reported. I still need to check into the head gaskets. I don't have the equipment to test compression right now, but I do plan on ordering what is needed soon. I do have an order in place for some cables to read the diagnostics from the computer. There is a shop two hours away from me that works on Hisun products, but I am hoping the problem can be identified and is something within my ability to handle. Below is what I've already investigated.  I am leaning towards the primary clutch needing replacement right now.
      After getting it home and unloaded, I did the following maintenance/checks to it prior to operating it further:
      Changed the engine/clutch oil (and filter) and gear oils using manufacture recommended viscosity Changed the air filter and checked for cracks in the air intake flow. Verified good suction. Cleaned the throttle body Changed the spark plug and verified the gap was within spec (0.6-0.7mm) Changed the coil and coil wire Changed the fuel lines, fuel injector, and verified the fuel pump was outputting the correct initial prime pressure for ignition and continuous pressure after ignition. Also completely emptied the fuel tank and made sure octane 91+ fuel is being used per manufacturer specs. Ran seafoam through system too. Cleaned the spark arrester and verified no cracks or gaps in the exhaust flow Changed out the O2 sensor Checked all wired connections to ensure they were secured and no breaks were visible Checked the belt for tightness and for any signs of wear and tear Verified 4WD and the differential lock function as expected - still hesitates and struggles uphill Verified the fan gears in the shifter are not corroded and working as expected ECU was reset after replacing sensors and fuel-related parts  
       
      Thanks!
    • By Bassarino51
      My 2014 Odes with less than 1000 miles suddenly won’t turn over with a fully charged battery.
×
×
  • Create New...