Quantcast
Jump to content


Recommended Posts

Posted

Mule still not charging after replacing a new regulator.  Need to figure out how to test the alternator at the plug on top of the motor.  Any easy way to check it?

Posted

Battery 2 months old.  Update is my stator is working.  I tested it on AC mode and it does good AC voltage.  Now I have to see why not charging still even after a new regulator.  So I will try to test it at the plug as shown in the vid you posted.

Posted

I had a guy come over and help as I don't know much about digital meters.  My stator seems to be doing ok.  Did a wire test from stator plug all the way to the regulator and then to battery.  No broken wires.  So it seems to be that I received a bad DOA regulator that I had ordered in so I will send it back and reorder then see

  • Like 1
Posted

UPDATE....   Well after this sites help and two different Regulators because the first one was D.O,A. the second one made it charge. I did find out that 610 Mule must use regulator part # 21066-0039 ONLY. My unit only uses 4 of the 5 pins in the connector going to the regulator. The middle pin has no wires to it. THANKS,.

  • Like 1
Posted

I'm having the same problem on a Mule 600 two regulators and still not charging. My stator checks ok. Where did you get your regulator? Was it an aftermarket or Kawasaki OEM part?

  • Like 1
Posted

UPDATE, the new regulator worked well about 30 mins then not charging again, i had help making sure the stator was working and wires were all good, SO something must be shorting the regulators out since this is my second one. Anyone know what to check????

Posted
On 12/19/2019 at 9:26 AM, dalem said:

I'm having the same problem on a Mule 600 two regulators and still not charging. My stator checks ok. Where did you get your regulator? Was it an aftermarket or Kawasaki OEM part?

i have tried after market  and OEM , and both only lasted for about 30 mins.  And my stator checks ok too.  The guy helping me did a continuity check from the stator plug to the plug that plugs into the regulator and both those wires were fine and the other two wires goes from regulator plug to the battery.  All wires are good.

  • 2 months later...
Posted

you most likely  have an intermittent connection between reg and battery.  the reg can only handle a few open full load dumps before the electronics die.   retest connections to battery and ign sw (key ON).

old trick.......jumper in second wire in parallel with the 3 wires mentioned......if lives longer than 30 min.....you won...but need to find the bad connection

Posted

After trying everything possible, including replacing the wiring harness (used one) I replaced the regulator with a Kawasaki OEM part $131 not cheap but it's charging now. Those  cheap aftermarket regulators  are not compatible with Kawasaki's electrical system. I tried three and none of those worked. I have a 98 Honda 300 4 wheeler and I put an aftermarket regulator on it about  five years ago and it still works OK.  

  • Like 1
Posted
1 minute ago, dalem said:

After trying everything possible, including replacing the wiring harness (used one) I replaced the regulator with a Kawasaki OEM part $131 not cheap but it's charging now. Those  cheap aftermarket regulators  are not compatible with Kawasaki's electrical system. I tried three and none of those worked. I have a 98 Honda 300 4 wheeler and I put an aftermarket regulator on it about  five years ago and it still works OK.  

Yeeeeeeeow! $131!!

I just paid $75 for mine

Posted

I am new to the site and having the same issue with my 2011 610 4x4.

I replaced the regulator with a new one from Kawasaki, and still battery does not charge. Anyone else have and ideas ?

Thanks

Posted

Your Reg/Rect should have 5 wires. 

2 are AC input from stator........both G/W.....measure resistance (at R/R connector) of stator windings=.3 ohm ish----depends on meter.

Next perform a stator output load test....connect a 40W incandescent to the same wires at the R/R connector....start motor....should glow dim then brighter with higher RPMs.....don't rev until bulb burns out........shut engine down.

The next 3 tests check the current carrying capacity of the wires/connections.  A "load test" rather than a meter test will better identify the fault.  The load is a 12V headlight bulb with a rated current draw of 5 plus Amps......85/85W motorcycle headlight bulb works great.  Put 2 leads on the good filament terminals.  Test by connecting to the UTV battery.....note brightness.  Leave NEG (-) wire clipped to battery NEG (-) post for next 2 tests.

BR wire is dead with KEY OFF and 12V with KEY ON......might notice a slight dimming due to extra wire and fuse resistance in the harness.

WHT wire has only the fuse back to POS (+) battery post.......bulb should burn slightly brighter....no run to the IGN SW.

BLK/YEL is ground.......frame and battery (-) post.  SO REMOVE BULB CLIP FROM NEG AND CLIP TO POS POST.  Now the test is looking for a path back to the NEG post.  Touch NEG Post....bright.  Touch frame....bright.  Touch starter motor case....bright.  Touch the engine case....bright.  Touch WHT wire terminal in R/R connector...........BRIGHT.

Most common failure is the BLK/YEL ground to harness.....bullet connector.  The starter current GND wire (heavy) suffers from electro corrosion......i.e. the steel bolt in the AL case  at starter mount.

Posted

Wow , thank you for the amazing write up. I will try all of this in the coming week and let you all know how I make out.

I appreciate your time on this.

 

  • 2 weeks later...
Posted
On 2/27/2020 at 11:00 PM, dalem said:

After trying everything possible, including replacing the wiring harness (used one) I replaced the regulator with a Kawasaki OEM part $131 not cheap but it's charging now. Those  cheap aftermarket regulators  are not compatible with Kawasaki's electrical system. I tried three and none of those worked. I have a 98 Honda 300 4 wheeler and I put an aftermarket regulator on it about  five years ago and it still works OK.  

Glad you got it fixed, it did mine too.

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.



  • Similar Topics

    • By didgeridoo
      Hello, All!  I've decided to replace the traction batteries in my 2018 Sector E1 with a 48V Lithium set. They may be expensive, but I figure the Discovery Dry Cell are, too. I am not looking for the max driving range, as I have never received near the brochured range to begin with, but a good mix of charge/ get work done/ charge is what I am expecting.
      I have settled on the 48V EAGL kit from bigbattery dot com. Each battery pack provides 30Ah. The kit ships with a charger, as well. The packs would be physically connected in parallel (using a busbar) to one another, maintaining the 48V voltage, but together would be able to provide the amp draw the buggy pulls when going up hill or towing a rake (rated 320 max continuous Amps). This is in comparison to the serial connection the eight 6V lead batteries. Each of the EAGL batteries looks to have its own BMS; am I correct in thinking I will have to use their included charger rather than (simply) changing the onboard charger to lithium mode? The chemistry of the pack is LiFe PO4, for what it's worth.  I haven't torn anything apart yet (to diagram), so  I am not sure how the dash will interpret the AMP draw, but the kit I am looking at includes a dash mounted charge indicator.
      If anyone has completed a similar conversion, do you have any tips? Specifically, how did you remove the original batteries, and how did you secure the new ones? I am guessing that almost any change from the stock batteries would involve at least some modifications. Any tips would be appreciated, especially things I may have failed to consider. Thanks!
    • By jertex
      I bought a 2017 Stampede 900 last fall that was new, old stock with less than 5 hours on it thinking that I would be getting a relatively trouble free UTV as compared to buying a used Polaris or CanAm, or Honda, etc. It's been a little quirky, but reliable. What I thought was just a minor issue with this model, the difficulty in shifting between R, N, L, H, etc., was just a characteristic of this model is now a big problem. I had to climb two very steep trails to get to the upper meadow of our hunting property, which seemed to stress the UTV more than usual since I was carrying some lumber to work on a platform for a hunting blind, and when I went to shift into park, I felt something give and it would not shift out of low, but it did move up into high gear.  I couldn't get it to shift at all at that point and the shifter felt mushy for lack of a better word. I was able to get it down to the lodge and when I investigated, I discovered that the straight, metal tube portion of the shift cable had bent to almost 90 degrees (see pics). I'm positive that it had already had some deformation that had happened previously and it had the right amount of resistance to bend to the point where it was unusable. 
      I have two questions:
      1. I suspect that there must be some other issues that makes this UTV difficult to shift, and I'm wondering if this is a common problem and if someone could enlighten me on what could cause this to be difficult to shift?
      2. Have any of you had this happen and if so, how difficult is it to replace the shifter cable?
      Any other advice is welcome, this is the first UTV that I've ever owned, so I don't know much about working on these or maintaining them. I'm relatively capable when it comes to working on my own vehicles in general, and I'm not afraid to take things apart and get my hands dirty.
      Thanks in advance for any insight, I'll be traveling most the day so I won't get a chance to look at replies until this evening.


       
    • By Debbie Hogan
      I realize this part is discontinued but im trying to find this exhaust pipe fir my dads 550.  His brother who has since passed bought this mule for my dad who is now 90 and he is trying to fix everything on it.  I'm willing to take a used one.  A new one would be great if someone still had in stock.  I'll take anything as long as it is in workable condition.   If anyone has any ideas for me im open to hearing them.  Thank you so much.
       
      Debbie fm  Texas
    • By lincolnsq175
      Ive searched and cannot find any performance parts that fit my machine.
      I have a 2020 coleman ut400.
      Im looking for machined sheave kit, programmers, cdi, exhaust and intake.
      I know these are yamaha rhino clones but are they rhino 450 clones?
       
      Any info is appreciated.
    • By MilSurpYinzer
      I heard there's several off road festivals out that way. One or two post apocalyptic, the rest just rev and run. Anyone know a good one that offers camping? Any advice for out of state people like hauling, legality, and where to stay?
      Ideally me and the missus would be down for camping out and setting up shop somewhere nearby. That way we can just wake up, load up, and ride.
×
×
  • Create New...