Quantcast
Jump to content

Hisun Utv 500 help


Jcherbert1

Recommended Posts

I'm wondering if someone can help me with an issue that has brought me to my wits end with my 2008 Hisun UTV 500.

This thing was running fine and it sputtered then died. I pulled the spark plug and there was no spark so I replaced the ignition coil, no luck. Then replaced the stator-magneto-pick up coil, still nothing. I then replaced the cdi with still no luck. I removed the wiring harness and went through it to look for any obvious issues and found only one, a capacitor at the rectifier connection which I replace as well with no luck. The spark plug was replaced today and same shit, nothing. The plug I have connected to an alligator clip and grounded to the engine. I know it has to be something simple but my simple mind cannot seem to figure it out. Any suggestions would help. 

  • Like 1
Link to comment
Share on other sites

  • 4 weeks later...
  • 3 months later...

You've replace all the components that can cause loss of spark.  Is the gap between the pickup coil and the pulse rotor close?  Gap shouldn't be much more than the thickness of a business card.  I don't know if it is adjustable on your machine.  Check your ground connections.  Do you have battery voltages where they should be with the ignition switch on?  You may have to find a Hisun dealer.  I can only find general diagrams for CDI systems, nothing specific to your machine.

Link to comment
Share on other sites

  • 2 years later...
  • 1 year later...

Hi, I have the same problem, and the electric furl pump can not run. At end, I make a new ground negativ directly at the electric pump, and all is OK. I don’t where is the problem before, I chek all parts, and at end only the negativ don’t be correct at the electric fuel pump. I write from panama, and here many sellers and nobody  to help you for Hisun.

the problem, it’s difficult to found a repair service manual for Hisun 500 ES year 2018 

It’s very easy

Link to comment
Share on other sites

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

  • Similar Topics

    • By Steve B
      My "R" light on the dash will not go out when I take the UTV out of reverse and put it into any other gear. Is this just the light switch issue or will this effect engine performance in the other gears?
    • By Ermd ttk
      Hello friends,
      I got my ODES Ravager UTV yesterday and after a couple of hours of driving when I go downhill I heard a strange loud noise a couple of times, like a gear skipping or maybe something from the differential.
      It doesn't always happen and when it does it is heard for a few seconds and then it goes away and everything works normally, I'm worried if there could be some major malfunction or what could be the problem if someone can help me?
      Thanks a lot.
       
    • By Travis
      View File Kawasaki Mule 550,520,500 Complete service manual
      This is a complete service manual for the Kawasaki Mule 500,520 and 550 models.
      Topics  covered include Brakes, Steering, Electrical system, suspension and fuel system. As well as engine repair procedures and Transmission/Final Drive procedures.
       
      ********************************************************************************************************************************************************************************************
      If you need more information about the engine this manual linked below is chock full of information.
      Thanks goes to @cliffyk for getting these files all  into one PDF format for uploading.
      Submitter Travis Submitted 04/18/2021 Category Kawasaki  
    • By ETHIEL
      Spark plug keeps fouling. after 10-15 minutes of running any ideas what to look fore 
    • By lonerider98
      At the end of last year my Coleman UT 500 will not go into reverse. I can hold it over toward the reverse to move it nut it won't lock into reverse. Anyone have this problem? Winter is just about over and going to have to get this resolved. Thank You!
×
×
  • Create New...